Campaigns on record across the Volvo Wxll (1995–2004), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with Volvo to confirm which apply.
On certain vehicles, the body builder wiring option was mis-wired in such a way that the Auto Neutral with Service Brake Status option may allow the transmission to go into forward gear without the drivers foot pressing down on the brake pedal first. Correction: Dealer will install an additional air operated stop light switch and perform the necessary wiring changes.
2003222 · 221 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2003 volvo wxll recalls
ON CERTAIN HEAVY-DUTY CLASS 8 VEHICLES, THE BODY BUILDER WIRING OPTION WAS MIS-WIRED IN SUCH A WAY THAT THE AUTO NEUTRAL WITH SERVICE BRAKE STATUS OPTION MAY ALLOW THE TRANSMISSION TO GO INTO FORWARD GEAR WITHOUT THE DRIVER'S FOOT PRESSING DOWN ON THE BRAKE PEDAL FIRST.
UNINTENDED MOVEMENT OF THE VEHICLE COULD PUT PERSONS IN DANGER INSIDE AND OUTSIDE THE VEHICLE.
VOLVO TRUCKS WILL NOTIFY ITS CUSTOMERS AND INSTALL AN ADDITIONAL AIR OPERATED STOP LIGHT SWITCH AND THE NECESSARY WIRING CHANGES. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT 1-800-528-6586.
03V308000 · 3,426 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2004 volvo wxll recalls
ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.
IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ELECTRONIC CONTROL MODULE CALIBRATION FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357 OR VOLVO TRUCK AT 1-800-528-6586.
03V183000 · 120 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2003 volvo wxll recalls
On certain vehicles, the upper forward and/or rear drive axle seat may break potentially allowing the affected axle to shift out of alignment. This condition could result in loss of axle stability and potential for vehicle crash. Correction: Dealer will replace suspect upper axle seats.
2003122 · 40 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2002 volvo wxll recalls
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS WITH VOLVO B-RIDE REAR SUSPENSION, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT COULD BREAK ALLOWING THE AFFECTED AXLE TO SHIFT OUT OF ALIGNMENT.
THIS CONDITION COULD RESULT IN LOSS OF AXLE STABILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE UPPER AXLE SEAT ON BOTH REAR DRIVE AXLES. OWNER NOTIFICATION BEGAN JANUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
02V317000 · 213 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2002 volvo wxll recalls
On certain heavy duty class 8 trucks the forward and/or rear drive axle upper axle seat can break allowing the axle to shift out of alignment. This could result in a loss of axle stability increasing the risk of a crash. Correction: Dealers will replace the upper axle seats.
2002062 · 16 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2001 volvo wxll recalls
Certain heavy duty class 8 vehicles equipped with electronic throttle control/accelerator pedals supplied by Williams's controls industries. The weld attaching the clevis to the plate has insufficient penetration and could allow the clevis to separate from the plate. If the clevis separated from the plate while the vehicle was in use, the vehicle would return to idle, increasing the risk of a crash. Correction: Dealers will replace these pedals.
2002020 · 9 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2001 volvo wxll recalls
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT CAN BREAK ALLOWING THE AXLE TO SHIFT OUT OF ALIGNMENT.
THIS COULD RESULT IN A LOSS OF AXLE STABILITY INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE UPPER AXLE SEAT FOR A CERTAIN DATE CODE THAT IS STAMPED ON THE PART, AND THOSE AXLES WILL BE REPLACED. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
02V036000 · 215 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2001 volvo wxll recalls
Certain trucks may have improperly heat treated drag link assemblies which can lead to premature wear of the ball socket. If this condition occurs, the driver can lose steering control, possibly resulting in a crash. Correction: Dealers will replace the defective drag links.
2001137 · 76 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 1999 volvo wxll recalls
VEHICLE DESCRIPTION: HEAVY DUTY, CLASS 8, TRUCKS EQUIPPED WITH TIE ROD ASSEMBLIES CONTAINING 24-DL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.
IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.
DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
01V044013 · 760 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 1999 volvo wxll recalls
1–10 of 19
Volvo Wxll by year
Related recall checks
Check recalls for specific Volvo Wxll model years