Campaigns on record across the BMW Z3 (1996–2004), from Transport Canada and, tagged NHTSA, the United States. Pick a model year for the Canadian listing, and check your VIN with BMW to confirm which apply.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
06E026000 · 61,944 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 2004 bmw z3 recalls
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR AXLE DIFFERENTIAL MAY CONTAIN RING GEAR BOLTS THAT WERE INCORRECTLY TORQUED DURING ASSEMBLY. THE BOLT OR BOLTS COULD LOOSEN LEADING TO NOISE FROM THE DIFFERENTIAL.
THE BOLT OR BOLTS COULD LOOSEN LEADING TO NOISE FROM THE DIFFERENTIAL AND IF A BOLT WERE TO COMPLETELY WORK LOOSE FROM ITS MOUNT, LOCKUP OF THE REAR AXLE COULD OCCUR.
DEALERS WILL INSPECT THE VEHICLE'S DIFFERENTIAL AND IF INVOLVED, WILL REPLACE IT.
99V272000 · 36 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 1999 bmw z3 recalls
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE NUT THAT SECURES THE MAIN POSITIVE CABLE TO THE POSITIVE BATTERY TERMINAL CLAMP WAS NOT TIGHTENED PROPERLY, ALLOWING THE CABLE TO LOOSEN OVER TIME. IF THIS OCCURRED, THE CABLE COULD ULTIMATELY LOOSEN TO THE POINT WHERE ELECTRICAL CONTINUITY COULD BE INTERRUPTED.
IF THIS OCCURED WHILE THE ENGINE WAS RUNNING, THE ENGINE COULD STOP. ALSO, IF THE VEHICLE WERE BEING OPERATED AT NIGHT, THE LIGHTING SYSTEM COULD SHUT OFF, INCREASING THE RISK OF A CRASH.
DEALERS WILL TIGHTEN THE NUT TO THE PROPER SPECIFICATIONS.
98V275000 · 1,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 1999 bmw z3 recalls
On certain 318IC, 318IS, 318TI, 325I, 325IC, 325IS, 525I, 525IT, 530I, 530IT, 540I, 740I, 740IL, 840CI and M3, the cruise control and throttle cable are attached to the same throttle valve actuating lever at the throttle housing. It is possible that the plastic bushing on either cable could break causing the outer cable housing to separate from the bushing. Throttle pedal application without cruise control engagement could cause the outer tube to catch on the edge of the broken bushing resulting in the throttle valve remaining partially open. If this were to occur, the car might not decelerate as expected and a crash could occut. Correction: A spring clip will be installed on the outer tube of each cable to prevent dislodgment from the bushing.
1997173 · 17,879 units in campaign · Transport Canada
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 1997 bmw z3 recalls
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
97V131000 · 410,000 units in campaign · NHTSA
Applies only if the manufacturer confirms your VIN · repair by an authorised dealer · All 1997 bmw z3 recalls